针织服装QC英语/中文
armhole pucker 袖窿起皱,夹圈起皱
bad join stitching,poor repair stitching 接线不良, broken hole 破洞 broken stitch 断线 broken yarn 断纱 bubble 起泡
bump at placket edge 门襟边扣眼位凸起,
center back ride up,center back seam pulling 后中起吊 checks not match 对格不良
collar points high/low 领尖高低,领尖不对称(不在同一水平线) color shading,color deviation 色差 color fading 褪色,
color fibre woven in 杂色纤维织入(面料上有杂色纱线) color shading within one garment (同件衣服内)裁片色差
color thread end left inside,trapped color thread end 藏色线(撞色线头被车在衣服封闭部位内) color too dull/bright 颜色太哑/闪 color yarn 杂色纱 crease mark 摺痕
crotch cro unmatch 裤裆十字骨错位 crumple at top collar 领面起泡,领面起皱 cuff edge not level 袖口边不平齐 defect 疵点,
dirty dot (较小的)污点
dirty mark,dirty stain 污渍,污迹 dirty spot (较大的)污点
drop needle 漏针,抽针,抽条,抽窿 exce extension 突咀
exceive thread end 多余的线头,漏剪的线头 fabric defect 布疵
fabric too close to zipper 面布车得太贴近拉链
facing leans out from front edge 前襟止口反吐(里料外露) fly up 飞起,翘起
glaze mark (熨烫)起镜,起极光 grin 露齿,裂口
hem not level 下摆边不平齐, hiking up 起吊
horizontal seams not level 水平缝骨(左右)没对齐 iron mark 烫痕 knit fault 织疵 knot 结头 loom fly飞花织入
major defect 大疵,严重疵点, material defect 布疵
minor defect 小疵,轻微疵点, mix color yarn 杂色纱织入(面料中) neck drop pucker 门襟顶部起皱, needle damage (缝针导致的)面料损坏 needle hole 针洞,针孔 off grain 丝缕歪, off size 尺寸不合 oil stain 油渍
open seam,seam opening 开缝,裂缝,]爆口 outseam/inseam pulling (侧缝/内缝)吊脚 placket bottom spread open 门襟豁, placket wavy 门襟起波浪(不平伏), pleated sewing 车缝打褶
pocket opening spray open 袋口豁, pockets high/low (左右)口袋不对称, poor back stitch 回针不良, poor ironing 烫工不良 poor linking 连接不良 preing mark 烫痕,压痕 printing scrimp 印花起裂 pucker 起皱
run off stitch (车缝)落坑,下坎, rust 锈迹
shoulder pucker 肩缝皱 skipping stitch 跳线
sleeve leans to back 袖子偏后 sleeve leans to front 袖子偏前 stitch not in seam shadow 露暗线 stitch density uneven 线迹密度不均匀 stitch tension uneven 线迹张力不均匀 stripes not match 对条不良 stripy 色挡,色花
support stitch visible 辅助线外露,定位线外露 thick yarn 粗纱 thread end 线头
top collar too tight 领面紧 total different color 颜色完全不同 underpre 熨烫不够 undesirable odor 臭味 uneven collar 歪领
uneven color 深浅色,颜色不均匀 uneven length of plackets 里外襟长短, uneven length of sleeves 左右袖长不等,长短袖 uneven lips (袋口)嵌线宽不均匀, water stain 水渍 wrinkle 起皱
wrong color combo 颜色组合错误 wrong pattern 图案错误 wrong seam type 缝骨类型错 wrong side 反面
wrong size indicated 错码 yarn drawn out 抽纱 yarn end 毛头
zipper not movable 拉链难以开合 zipper wavy 拉链起波浪,拉链起蛇